Page 1 of 2

Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 17:27
by Tiny Howarth
:helpsign: When i turn the dash knob to on, the ABS and diff lock light flashes, can anybody give me some advice as to where i should start to look for the fault?

Re: Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 18:41
by Tinus lotz
Your patrol needs to be in 4 wheel low first ....solinoid or pipes mabe?

Re: Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 19:40
by Herrie
You can also take out the switch on the diff to make sure it is clean - I had to clean mine because the pin did not move.

Re: Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 19:44
by Herrie
One of the vacume pipes was also blocked and I had to cut off a piece and replace it with a rubber pipe.

Re: Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 20:24
by Peter Connan
Tiny, a couple of questions first:
1) is the vehicle in 4L
2) Have you tried driving slowly in a circle or weaving from side to side?

Re: Rear Diff Lock problem, need advice

Posted: 30 Sep 2014 22:00
by Trailerman
My 98 Patrol het dieselfde probleem gehad, was toe die skakelaar op die dash wat nie mooi kontak gemaak het nie.
Uitgehaal en mooi skoongemaak, einde van probleme.
Soos genoem moet die Patrol in low range wees!!
Groetnis

Re: Rear Diff Lock problem, need advice

Posted: 01 Oct 2014 09:43
by Alex Roux
I may be mistaken (and I will check to night) but I am pretty sure on the Y61 the diff lock can engage in either 4H and 4L?!
Just the Y60 that can do it in 2H which the Y61 cannot do.

Re: Rear Diff Lock problem, need advice

Posted: 01 Oct 2014 10:39
by Marino4x4
My 4.5 can engage the Diff Lock in 4H and 4L. Attached is the diff-lock layout.
Diff Lock.pdf
(158.31 KiB) Downloaded 545 times
The vacuum comes fro the engine. It is swished between locked and open with a solenoid valve on the left side of the car via the control in the cabin. It then runs to the actuator in the back. There is an electrical switch on the diff with the actuator. Anny of these can give a problem. Take some compressed air and clean the piping. Q20 the switch and electro/contactor clean the cabin switch.

Good Luck

Re: Rear Diff Lock problem, need advice

Posted: 01 Oct 2014 17:05
by Tiny Howarth
Tinus lotz wrote:Your patrol needs to be in 4 wheel low first ....solinoid or pipes mabe?
Oops will do the 4 wheel low the weekend and try then, thanks :redface:

Re: Rear Diff Lock problem, need advice

Posted: 01 Oct 2014 17:07
by Tiny Howarth
Herrie wrote:You can also take out the switch on the diff to make sure it is clean - I had to clean mine because the pin did not move.
Will try to engage when in 4 wheel low first the week end, will give feedback, i did not know, first put in 4 wheel low. :redface: