Diesel leak
- DH70
- Senior Member
- Posts: 72
- Joined: 19 Jul 2016 15:51
- Full Name: Donald Hastie
- Nickname: Donnie
- Home Town: Melkbos
- Current 4x4: NA
- Home Language: Afr, Eng
- Has thanked: 17 times
- Been thanked: 6 times
Diesel leak
This is probably like asking a doctor to diagnose you over the phone, but here goes.
I have diesel dripping from a bracket on the engine block onto the middle of the front dif, not much, but enough to have the diff wet within 3 hours after cleaning the engine. I can't see where it's coming from, any ideas what it could be?
I have diesel dripping from a bracket on the engine block onto the middle of the front dif, not much, but enough to have the diff wet within 3 hours after cleaning the engine. I can't see where it's coming from, any ideas what it could be?
- Alex Roux
- Patrolman 1000+
- Posts: 2629
- Joined: 11 Jul 2011 10:54
- Full Name: Alexander Roux
- Nickname: Calculator
- Home Town: Johannesburg
- Current 4x4: 2004 GU 3TDi (Lexus) - aka "Witblits" (sold)
2005: GU TD42 - aka "Masewa"
1996: GQ TB48 conversion - aka "Skilpad"
1993: GQ SWB TB42 - aka "Shortie"
1985: MQ Patrol (Safari) SD33 - aka "Toro" - Home Language: Afrikaans
- Has thanked: 49 times
- Been thanked: 240 times
Re: Diesel leak
Does it only leak when the engine is running?
Check the clamps on the fuel pipes. Follow the fuel line from the tank to the engine.
I've had a clamp that damaged the pipe and leaked at that point, but only while the engine was running. I.e. while there was pressure from the pump towards the engine.
Check the clamps on the fuel pipes. Follow the fuel line from the tank to the engine.
I've had a clamp that damaged the pipe and leaked at that point, but only while the engine was running. I.e. while there was pressure from the pump towards the engine.
Skilpad, Shortie, Toro & Masewa
- DH70
- Senior Member
- Posts: 72
- Joined: 19 Jul 2016 15:51
- Full Name: Donald Hastie
- Nickname: Donnie
- Home Town: Melkbos
- Current 4x4: NA
- Home Language: Afr, Eng
- Has thanked: 17 times
- Been thanked: 6 times
Re: Diesel leak
Alex, not sure, will clean diff tonight after parking in garage and check tomorrow morning.
- Alex Roux
- Patrolman 1000+
- Posts: 2629
- Joined: 11 Jul 2011 10:54
- Full Name: Alexander Roux
- Nickname: Calculator
- Home Town: Johannesburg
- Current 4x4: 2004 GU 3TDi (Lexus) - aka "Witblits" (sold)
2005: GU TD42 - aka "Masewa"
1996: GQ TB48 conversion - aka "Skilpad"
1993: GQ SWB TB42 - aka "Shortie"
1985: MQ Patrol (Safari) SD33 - aka "Toro" - Home Language: Afrikaans
- Has thanked: 49 times
- Been thanked: 240 times
Re: Diesel leak
Donnie
Just to be clear I am no expert at this, but I would suggest:
Get an old T shirt on, get under neath the car (at least Patrols have die clearance to make this possible), and follow the fuel line. Especially in the vicinity of where you saw the drops. Then ask somone to start the engine, while you hold a little torch up. It could be as simple as a clamp that cut the pipe.
At least it is diesel, a petrol leak can make you VERY nervous.
Just to be clear I am no expert at this, but I would suggest:
Get an old T shirt on, get under neath the car (at least Patrols have die clearance to make this possible), and follow the fuel line. Especially in the vicinity of where you saw the drops. Then ask somone to start the engine, while you hold a little torch up. It could be as simple as a clamp that cut the pipe.
At least it is diesel, a petrol leak can make you VERY nervous.
Skilpad, Shortie, Toro & Masewa
- ricster
- Patrolman 1000+
- Posts: 5850
- Joined: 13 Jan 2010 11:16
- Full Name: Cedric Warner
- Nickname: Cedric
- Home Town: Alberton Gauteng
- Current 4x4: '99 Nissan Patrol 4.2 Turbo Diesel
- Home Language: English
- Location: LA..... No not Los Angles ..... Lower Alberton, Gauteng
- Has thanked: 591 times
- Been thanked: 468 times
Re: Diesel leak
Can you put a few pics up from different angles of the motor?
If the motor runs and drives with the same amount of power and is as smooth as a TD42 motor can be, then I'm thinking that it will be a return line from the injectors back to the tank. I say this assuming it is quite a serious leak which if on the inlet side of things, will reduce the diesel pressure going into the injector pump and or injectors. I doubt very much that it is a leak from the injector pump to the injectors as that is under a much higher pressure, but stranger things have happened.
Like Alex said, get under the motor and follow the fuel lines from the tank to the filter and then to the IP. Also check from the spill rail ( the small metal tube thingy that connects all 6 injectors together ) as this sends the unused diesel back to the fuel tank. There is also a small rubber hose if I recall that connects the spill rail to the return pipe to the IP ( which will via the IP send the unused diesel back to the tank ). Age and heat could have degraded that piece of pipe causing a leak. This small pipe is a little tricky to see, as it fits in between the intake manifold ( between no 3 and no 4 cylinders if I recall ) and connects to the top near the back of the injector pump
This is the pipe I'm talking about....
And this is where it fits onto the IP.....
If the motor runs and drives with the same amount of power and is as smooth as a TD42 motor can be, then I'm thinking that it will be a return line from the injectors back to the tank. I say this assuming it is quite a serious leak which if on the inlet side of things, will reduce the diesel pressure going into the injector pump and or injectors. I doubt very much that it is a leak from the injector pump to the injectors as that is under a much higher pressure, but stranger things have happened.
Like Alex said, get under the motor and follow the fuel lines from the tank to the filter and then to the IP. Also check from the spill rail ( the small metal tube thingy that connects all 6 injectors together ) as this sends the unused diesel back to the fuel tank. There is also a small rubber hose if I recall that connects the spill rail to the return pipe to the IP ( which will via the IP send the unused diesel back to the tank ). Age and heat could have degraded that piece of pipe causing a leak. This small pipe is a little tricky to see, as it fits in between the intake manifold ( between no 3 and no 4 cylinders if I recall ) and connects to the top near the back of the injector pump
This is the pipe I'm talking about....
And this is where it fits onto the IP.....
Regards
Cedric
Nissan Patrol GL 4.2 Diesel Turbo (Iron Maiden)
Nissan SANI 3.0 V6 4x4 (SOLD)
Isuzu KB 280 DT 2x4 ('ol Smokey) - SOLD
Suzuki TL 1000R "V twin" (Growler) - SOLD
Cedric
Nissan Patrol GL 4.2 Diesel Turbo (Iron Maiden)
Nissan SANI 3.0 V6 4x4 (SOLD)
Isuzu KB 280 DT 2x4 ('ol Smokey) - SOLD
Suzuki TL 1000R "V twin" (Growler) - SOLD
- DH70
- Senior Member
- Posts: 72
- Joined: 19 Jul 2016 15:51
- Full Name: Donald Hastie
- Nickname: Donnie
- Home Town: Melkbos
- Current 4x4: NA
- Home Language: Afr, Eng
- Has thanked: 17 times
- Been thanked: 6 times
Re: Diesel leak
Followed Ricster's advice, but there's no leaks visible. (can't load pics, even via flickr)
Got underneath with motor running as Alex suggested, can't see anything.
Next stop....mechanics.
Got underneath with motor running as Alex suggested, can't see anything.
Next stop....mechanics.
- ricster
- Patrolman 1000+
- Posts: 5850
- Joined: 13 Jan 2010 11:16
- Full Name: Cedric Warner
- Nickname: Cedric
- Home Town: Alberton Gauteng
- Current 4x4: '99 Nissan Patrol 4.2 Turbo Diesel
- Home Language: English
- Location: LA..... No not Los Angles ..... Lower Alberton, Gauteng
- Has thanked: 591 times
- Been thanked: 468 times
Re: Diesel leak
.....hmmmm... you got me stumped bud !!
Keep us posted as to what the mechanics recon.
Keep us posted as to what the mechanics recon.
Regards
Cedric
Nissan Patrol GL 4.2 Diesel Turbo (Iron Maiden)
Nissan SANI 3.0 V6 4x4 (SOLD)
Isuzu KB 280 DT 2x4 ('ol Smokey) - SOLD
Suzuki TL 1000R "V twin" (Growler) - SOLD
Cedric
Nissan Patrol GL 4.2 Diesel Turbo (Iron Maiden)
Nissan SANI 3.0 V6 4x4 (SOLD)
Isuzu KB 280 DT 2x4 ('ol Smokey) - SOLD
Suzuki TL 1000R "V twin" (Growler) - SOLD
- Grant
- Patrolman 1000+
- Posts: 1269
- Joined: 29 Apr 2009 14:52
- Full Name: Francis
- Nickname: Grant
- Home Town: Rosendal
- Current 4x4: 2020 70 Series V8 LC
Hilux 2,4 4x4 SC Dakar - Home Language: English
- Location: Eastern Free State
- Has thanked: 3 times
- Been thanked: 25 times
Re: Diesel leak
The reason for the leak is the Patrol is letting you know that you need to stop driving like a granny and give it gas.
V8 Power
You can't expect to be old and wise
if you were never young and crazy
You can't expect to be old and wise
if you were never young and crazy
- DH70
- Senior Member
- Posts: 72
- Joined: 19 Jul 2016 15:51
- Full Name: Donald Hastie
- Nickname: Donnie
- Home Town: Melkbos
- Current 4x4: NA
- Home Language: Afr, Eng
- Has thanked: 17 times
- Been thanked: 6 times
Re: Diesel leak
I give it heaps of gas, but it still drives like a granny. Maybe I must drive the clutch more and keep the revs in the red to simulate faster driving.
Who is online
Users browsing this forum: No registered users and 0 guests